Certifiable Situational Awareness & BVLOS Solutions for Uncrewed Aircraft Systems in the Defense & Civil Industries

UAS Pipeline Inspections Simulated in NASA SIO Demonstration

By Sarah Simpson / 05 Mar 2021
Follow UST

Sagetech Avionics has partnered with Echodyne to provide a multi-sensor Detect and Avoid (DAA) system to American Aerospace Technologies Inc. (AATI), as part of NASA’s final Systems Integration and Operationalization (SIO) demonstration flight.

In partnership with the Federal Aviation Administration (FAA) the SIO demonstration series is to show potential commercial applications using different sizes of unmanned aircraft systems (UAS) in a variety of locations and different airspace classes. SIO aims to accelerate the safe integration of UAS for commercial applications into the national airspace system.

American Aerospace Technologies Inc. AiRanger UAS

AiRanger UAS (Photo: American Aerospace Technologies Inc)

AATI flew its AiRanger UAS for approximately one hour and 57 minutes from the Elk Hills-Buttonwillow Airport in California, ranging out 14.5 miles and returning. Flying over rural, sparsely populated areas, the AiRanger was operated by a remote pilot based at a ground control station.

Complex coordination with the FAA, the Federal Communications Commission and local authorities was required for the flight to occur. The FAA approvals were accomplished for AATI’s flight through an arrangement with the New Jersey Institute of Technology to operate as one of the FAA’s UAS test sites.

In addition to AATI’s Command and Control (C2) radio used to communicate with the aircraft, provided by Collins, the flight demonstration included two technologies necessary to fly safely in the national airspace – the Sagetech Avonics/Echodyne DAA system, designed to allow the pilot on the ground to “see and avoid” other air traffic, and OneSky Systems’ real-time UAS traffic management (UTM), which integrates vehicle telemetry, radar tracks, automatic dependent surveillance-broadcast, and weather data for situational awareness.

The C2 radio, as well as the payload radio from Cubic, communicated through a Troll MT-300 high-gain tracking antenna. AATI is also engaged in a long-term activity with End State Solutions for FAA type certification of this aircraft.

AATI used the demonstration to represent how its AiRanger UAS could survey miles of petroleum pipeline using the installed InstaMap detection system to find faults or hazardous conditions in the pipes. This system could be used in remote areas with thousands of miles of pipeline like those in Alaska and across the U.S.

The AiRanger weighs up to 220 pounds, has a wingspan of 18 feet 5 inches and a length of 9 feet 6 inches. It can carry combined payloads and fuel up to 65 pounds, flies using a catapult launch system, and lands on a belly skid.

“This commercial UAS demonstration offers a glimpse of the future as UAS like the AiRanger routinely and cost-effectively perform pipeline patrol missions, which is vital to keeping our environment safe,” said John Del Frate, NASA SIO senior project engineer. “With pipeline patrol typically occurring in remote locations, it’s a perfect starting point for UAS to gain the data and experience necessary for flight in more complex airspace.”

NASA’s role in SIO is to leverage years of research in DAA and C2 systems to facilitate discussions and provide technical insight as technology and policy evolve for UAS larger than 55 pounds for commercial uses.

The goal is to work with industry to help incentivize the creation of C2 and DAA systems based on standards informed by years of NASA research under the Unmanned Aircraft Systems (UAS) Integration in the National Airspace System (NAS) project. DAA and C2 are key systems needed to enable the safe integration of UAS into the NAS. The conclusion of the SIO project is being carried out under the Advanced Air Mobility (AAM) project.

SIO’s other industry partners are General Atomics Aeronautical Systems Inc. (GA-ASI) and Bell Textron Inc. who both completed flight demonstrations in 2020. All the SIO flight demonstrations have occurred at altitudes above 500 feet.

NASA plans to document best practices and lessons learned from the SIO activity and provide it to the UAS community to increase industrywide progress toward routine commercial unmanned aircraft operations.

To learn more, contact Sagetech Avionics: Visit Website Send Message View Supplier Profile
Posted by Sarah Simpson Specialising in digital copy Sarah is an experienced copywriter and researcher. Working with Unmanned Systems Technology Sarah has developed a passion for sourcing unique digital content and a talent for writing about the latest technical innovations in the unmanned sector. Connect & Contact